I know, the title is too long but depending on where your interests lie…
And yes, the babies are boys but this was my best photo…
Treadle has two soft Japanese double layer pique knits, one pink, one blue. A bit spendy and only 32″ wide but in my mind that said, “Baby Layette Blanket”. All I had to do was finish the edges and since we have had quite a few serger classes lately and we often got the question, “What do you use the 3 thread overlock for?” I thought I might share what I did.
For the blue three thread I used off white Jeans Stitch cotton thread in the upper looper along with a heavier poly/cotton Gutermann denim thread that I had picked up at the Expo in the lower looper.
For the four thread I used Pearl Crown Rayon in the upper looper and Heavy XP Coats and Clark in the lower looper-serger thread in needles.
I didn’t prewash the fabric as I didn’t want the layers to separate before sewing. The fabric did shrink 4 inches both ways but it also got thicker and the pique showed more.
I tried to take photos of turning corners without cutting threads but my camera didn’t have high enough resolution. We teach this method in our Beyond Basic Sergery (Treadle) or Advanced Serger (Make It Sew) classes. Practice makes perfect.
Here is the written version from the Babylock website, check out a serger book and you will find it too.
“Outside Corners: Stitch to the end of the corner edge, but not beyond. Stop with the needles up and raise the presser foot. With tweezers pull approximately 1/4″ of slack thread above the needles. The slack will allow the fabric to be pulled slightly to the back, clearing stitches from the stitch fingers. Turn the fabric, aligning the new edge with the edge of the needle plate. Remove any slack from the needle threads. Lower the foot and continue sewing.”
I was only trimming the tiniest edge off the fabric but if you trim more you will need to trim by hand for about 2″ at the beginning of each corner. You’ll see what I mean if you try it-the blade won’t get a chance to cut right at the very beginning and that will make everything gum up.
Can’t wait to wrap up babies in these blankets!